16 yzf450 wont idle

Buffstar109
Hey guys, went out riding at the weekend. Got 5 laps then the bike cut out under braking and wouldn't start. Bikes at 50 hours and never missed a beat until now. Back at the van I got it to start but won't idle. Since then I've Tried adjusting the idle screw, cleaned all the electrical plug connections, drained the tank and blew out the fuel line. Still won't idle. I run a vortex ignition and it takes throttle fine when it starts. I put on the stock ignition it still won't idle but also starts breaking up around half throttle. Votrew is back on and taking throttle ok but just won't idle. Any ideas? Thanks in advance
|
kb228
Profile picture for user kb228
Posts
6161
Joined
1/31/2018
Location
Mansfield, OH US
kb228 8/6/2018 7:48am
8/6/2018 7:48am
Could be a list of issues man. Fuel pump, dirty injector, stator/rectifier issues.
1
Buffstar109 8/7/2018 1:42pm
8/7/2018 1:42pm
So I've cleaned out the throttle body, checked the timing. Will start but won't run at all with the vortex ignition on. I put the stock ignition on and it starts idles and runs fine, until half throttle then breaks up. Tried the vortex back on still won't run. Stock on again and idleing and running fine till half throttle. I tested the fuel pump seems fine on a battery. I'm leaning toward the tps? Any thoughts?
kb228
Profile picture for user kb228
Posts
6161
Joined
1/31/2018
Location
Mansfield, OH US
kb228 8/7/2018 2:10pm
8/7/2018 2:10pm
Im still set on stator rectifier
Paw Paw 271
Profile picture for user Paw Paw 271
Posts
3640
Joined
4/3/2013
Location
Benton, LA US
Paw Paw 271 8/7/2018 7:47pm
8/7/2018 7:47pm Edited Date/Time 8/7/2018 7:48pm
Weak fuel pump and or clogged fuel filter. It is starving for fuel.

Paw Paw

The Shop

See All »
Buffstar109 8/8/2018 5:11am
8/8/2018 5:11am
Thanks guys, any idea of either of those faults would show up on a diagnostics tool?
kb228
Profile picture for user kb228
Posts
6161
Joined
1/31/2018
Location
Mansfield, OH US
kb228 8/8/2018 5:18am
8/8/2018 5:18am
Not 100% sure. A dead or faulty pump would. Clogged injector wouldnt. Broken injector would. Not sure if the ecu marks low supply voltage from the rectifier as a fault but it could i suppose. Im not that familiar with yamahas ecu codes. A service manual will have every fault listed and why that fault gets triggered.
Buffstar109 8/12/2018 6:32am
8/12/2018 6:32am
Hey guys. Got it on the diagnostics and fault 14.air intake pressure sensor. Swapped it out from a friend's bike and away it went good as new.

Post a reply to: 16 yzf450 wont idle