Added reply in a thread Suzuki Rm 250 / Keihen pwk 37mm 10/9/2019 4:13 PM

Update... so I have done a leak down test. I've found a good leak on the pipe intake on the motor side. My intake is super hard like a rock. It's very hard to even get the carb in. So I've ordered a new one and the gaskets, along with L / R crank seal,

... more »
Added reply in a thread Suzuki Rm 250 / Keihen pwk 37mm 10/7/2019 6:09 PM

Will do... would a leak down / compression test help? Thanks for your help. My parts will be in this week, will see how it goes after rebuilding the carb, and installing the new gaskets. Also have better fuel to mix

Updated photo album Rm250 10/7/2019 5:36 PM

This photo album has no comments yet

Added reply in a thread Suzuki Rm 250 / Keihen pwk 37mm 10/7/2019 5:30 PM

Its was prior to tear down. Has about 7 hrs on it. Top and bottom end. But I just boxed it up. Was rebuilding everything else. This is the only issue I'm having now...

Added reply in a thread Suzuki Rm 250 / Keihen pwk 37mm 10/7/2019 5:17 PM

Yes it has... Ive been building the bike over the last couple of months. Carb was taken off and set to the side. But I cleaned everything before putting it up...

Updated bike check Zuki 10/7/2019 3:17 PM
Started new thread Suzuki Rm 250 / Keihen pwk 37mm 10/7/2019 3:04 PM

My Rm 250 is redlining itself after a few minutes after idle. My kill switch won’t even shut it down. Have to kill the fuel to get it to shut down....What would cause this? My fuel mixture is 37:1 I use castor 927 but had to use pump gas 91 octane. With ... more »

This forum thread has 9 replies

Liked a bike check 2004 Suzuki RM 125 "Gutless Wonder" 4/22/2019 7:38 PM
Liked a bike check RM250 2006 All Stock 4/22/2019 7:36 PM
Updated bike check Zuki 4/21/2019 7:39 AM
Updated bike check Zuki 4/21/2019 7:39 AM
Added bike check Zuki 11/25/2018 7:07 PM