Added reply in a thread Crappy clutch hose:) 7/24/2021 7:43 PM

Was told that the sun caused the outer coating to degrade on some of the years of Ktms and Huskys Seen worse than that Replace it...

Added reply in a thread Cr125 carb issues 7/22/2021 6:12 PM

Check the level and jetting specs

Added reply in a thread 15 crf 250r won’t start off kick start after rebuild. Help 7/22/2021 6:09 PM

Make sure decompression mechanism on cam is working properly it might be hanging up on using kick starter cause its not turning fast enough as when you bump start it

Added reply in a thread CRF Showa shock damping rod 7/22/2021 9:36 AM

Have to push out from top with something{long T allen or screwdriver}that fits in shaft It floats inside shaft

Added reply in a thread 2020 yz450f 7/20/2021 2:47 PM

How long have you ran it? are rings seated? smoke not good

Added reply in a thread 15 crf 250r won’t start off kick start after rebuild. Help 7/20/2021 7:18 AM

Clean the injector

Added reply in a thread Honda CRF250 need help! 7/13/2021 12:29 AM

Ck alignment of stator plate No new piston?

Added reply in a thread KTM 150SX Base Gasket Thickness 7/11/2021 9:58 PM

Send the old one to Greg and he should be able to sell the right one for his set up

Added reply in a thread KTM engine bearings will NOT come out 7/8/2021 7:40 AM

Use map gas to heat they should fall out

Added reply in a thread No spark 7/5/2021 11:45 PM

Sounds like you have covered most of the parts that could be in question but the wire harness might be the issue. I ran into this issue last week and the wiring was the issue. Smashed wires from the seat on the frame.

Added reply in a thread 2019 crf250r won’t start 6/29/2021 6:20 PM

Put stock lever on and reconnect see if it will run

Added reply in a thread Large shavings in motocross oil 6/26/2021 1:29 PM

Prob cam chain guide getting chewd up Pull stator cover and check inside

Added reply in a thread 17' Husky FX350 Map Switch Won't Shut Off 6/22/2021 8:31 AM

Pull the tank and see if a wire is grounding on the frame or broken connector

Added reply in a thread 06 kawasaki 450f no start 6/22/2021 8:24 AM

Don't trust the Dot on piston Check valve pockets on top of piston Have seen the Dot not needing to point to exhaust could be backwards

Added reply in a thread 13 Kawasaki 250F issue 6/12/2021 9:03 PM

Just rebuilt a pump from bike sitting for a long time-Allballs kit Go with new injector or hope you can clear yours out

Added reply in a thread YZ450 Power Drop when Hot 6/12/2021 8:00 PM

TRY RUNNING HALF AV GAS AN PUMP GAS COOLANT - ENGINE ICE OR LIQUID PERFORMACE

Added reply in a thread Bike shifts on stand but not riding 6/12/2021 7:50 PM

DID YOU CHANGE BEARINGS? DID YOU TAKE RACHET ASSEMBLY APART? CHECK ROLLER LEVER IS MOUNTED OR SEATED PROPERLY AND HITTING ALL DETENTD OF WHEEL

Added reply in a thread Last effort before splitting the cases rm250. Burning gear oil. 6/9/2021 6:57 PM

Have it welded and re machined How many hrs on cases? Was bearing welded to shaft?

Added reply in a thread Keihin Carb Hardware replacement 6/7/2021 10:16 PM

Most hobby stores selling RC models have them in packs Every philips head on a Jap bike is JIS

Added reply in a thread kx450f wont start 6/6/2021 6:09 PM

Did you solder wires or crimp? Why rewire?