Added reply in a thread 2017 ktm 50 sx sputtering top end 3/27/2020 10:14 AM

Just listened to vid. Did you take power valve apart for top end? or just pull complete cyl and head together. Sounds like powervalve stuck or not connected to diaphragm. Pull pipe put finger in to manually move valve.

Added reply in a thread 2017 ktm 50 sx sputtering top end 3/27/2020 9:57 AM

Look at the ground wires to the motor. You should have two connectors bolted in the same spot. one from coil an other from stator. I found working on three of these at the same time the coil wire(small eyelet)must be against the case first. It took many ... more »

Added reply in a thread 2017 ktm 50 sx sputtering top end 3/26/2020 8:08 AM

First , you have gone through most of the common parts. Post a picture of how the connectors are bolted to the case for ground. Could be the issue. A worn needle in carb have been known issues. Spark plug boot.

Added reply in a thread 350 SX-F Engine Idle Speed 3/25/2020 6:36 AM

i set all the KTM -Husky 4 strokes 1900-2000

Added reply in a thread AEO suspension 8/11/2019 8:44 AM

AEO in Murrieta is a New KTM-Husky dealer and a WP service center like its AZ shop They also are offering trackside support at local So Cal tracks You can call to find out what track they will be at to cover your needs for parts or service. They support ... more »

Added reply in a thread 17 fc350 18 battery swap 12/15/2017 4:46 PM

WPS 490-2526

Added reply in a thread 14-17 Yamaha YZ450F Parts 10/29/2017 8:09 AM

Is the flywheel weighted?

Added reply in a thread Husky/KTM Remapping & *Stumbling Issue* 6/21/2017 9:21 AM

The US map is leaner for EPA reasons

Added reply in a thread Husky/KTM Remapping & *Stumbling Issue* 6/20/2017 11:28 AM

Try Proven Moto, Race Tech, If you can get a dealer to drop the Euro map in it you'll be good.

Added reply in a thread 2016 ktm 250sxf won't start 5/21/2017 10:16 AM

Pull all connections apart and use contact cleaner and compressed air. Since you are going to take the connections apart use dielectric grease around the connections. If that doesn't work and you still get backfiring, then it may have jumped time on ... more »

Added reply in a thread Ktm sxf 250 2016 electric start problems 5/21/2017 9:55 AM

Take a closer look at the wiring behind the # plate. The wires tend to break at the back of the connection. The way it is mounted from the factory allows the wires to bend up and down and they break. I like to take the connection out of the holder and ... more »

Added reply in a thread KTM User Settings tool 3/19/2017 6:28 PM

coastie 44 sent pm

Added a comment to coastie44's profile 3/19/2017 6:27 PM
Factor E

sent u a pm

0 0 0

This user profile has 5 comments.

Started new thread Brand New 6D Youth Helmet 3/17/2017 9:39 PM

Brand New 6D youth size Lrg never worn $400 obo text only 714-925-9201

This forum thread has 1 reply

Added reply in a thread 2015 ktm 450 FE electrical help? 12/2/2016 9:44 PM

Check the wires to the switch behind the number plate. The connector is mounted side ways and the wires tend to break at the connector from bouncing up and down. Eliminate the connector and hard wire the starter switch.

Started new thread Moto Sprinter 10/5/2016 9:36 PM

For Sale: 2011 Mercedes Moto Sprinter Currently at dealer getting annual service In AZ and CA http://phoenix.craigslist.org/nph/cto/5812823390.html

This forum thread has 4 replies

Added reply in a thread Rear Shock Snap Ring 12/5/2015 9:08 PM

I've used this for yrs from Snap on Seal Remover, Spoon Tip, 5 11/32", Red 0 stars 11.45 USD Item: SGSR3AR

Added reply in a thread 2015 Yz250f 11/21/2015 10:26 PM

From you saying that you get a pop after a lot of kicks makes it sound like its a timing issue. Check your timing marks on the cams and at the fly wheel. Could be cam chain jump or if the marks don't line up at the flat wheel the woodruff key might have ... more »

Added reply in a thread Can any motor builder help? 11/3/2015 9:24 PM

Take the plugs out and kick them over to feel the difference. Kick mechanism may be binding.

Added reply in a thread 2014 KTM 250 sxf no spark no fuel pump power 11/3/2015 9:18 PM

Disconnect the tip over sensor and reconnect it, this resets it.