2016 yzf 250 dies while riding

Related:
Create New Tag

haber0051

Vital MX member haber0051
24060 haber0051 http://p.vitalmx.com/photos/users/24060/avatar/c50_90256850_1291605282.jpg?1294202747 http://www.vitalmx.com/community/haber0051,24060/all 12/05/10 9 9 25

Posts: 34

Joined: 12/5/2010

Location: Vancouver, WA USA

2/10/2016 3:18 PM

about 12 hours on it was running fine and just died,walked back to truck and it started back up and ran fine.took home cleaned and greased all wire connections.rode it another 2 hours all good .took down to marrysville to race qualifier this weekend and died going up face of jump yesterday,my son is scared to ride it now.when we take off gas cap you can hear air sucking in.has anyone had bad gas cap?


Wilkinson81

Vital MX member Wilkinson81
49132 Wilkinson81 http://p.vitalmx.com/photos/users/49132/avatar/c50_IMG_1762_1503477517.jpg?1503477506 http://www.vitalmx.com/community/Wilkinson81,49132/all 10/12/15 1 http://www.vitalmx.com/community/Wilkinson81,49132/setup 4 18

Posts: 22

Joined: 10/12/2015

Location: NZL

2/10/2016 11:16 PM

Cheek the spark plug cap mine did the same where the spark plug is can fill up with mud whn you wash it Thea's a small hole on the right hand side of the head just next to where the radiator hose goes in it's a drain hole but can get bloked whn washing and whn the motor gets hot some how pops the cap off pull the spark plug cap off and give it a good clean around the spark plug make sure all the dirts and and make sure it drains out the hole thn glue some foam under the tank so it sits hard down on the spark plug cap

sgrimmxdad

Vital MX member sgrimmxdad
39808 sgrimmxdad http://p.vitalmx.com/photos/users/39808/avatar/c50_TAG_1500658339.jpg?1500658046 http://www.vitalmx.com/community/sgrimmxdad,39808/all 07/23/13 1 37 690 1 1

Posts: 727

Joined: 7/23/2013

Location: Farmville, NC USA

2/11/2016 3:30 AM

Well being a 16 it shouldn't be the TPS. It sounds a lot like our 15 problems, which turned out to be the TPS. I agree with above check the spark plug cap. Good luck, please post your findings!

2016 YZ250F 2008 CRF450R
2015 YZ250F 2008 CRF250R
2012 YZ125 2001 CR250R
2010 YZ250 2012 CRF150R
2009 YZ125 2010 KX109.5
SSR Motorsports Dealer
TAGMX Suspension, featuring FCR Works products!

xnationalwrench

Vital MX member xnationalwrench
2984 xnationalwrench http://p.vitalmx.com/photos/users/2984/avatar/c50_618115028_1203301146.jpg?1294180761 http://www.vitalmx.com/community/xnationalwrench,2984/all 02/17/08 16 34 2971 11

Posts: 3005

Joined: 2/17/2008

Location: Champaign, IL USA

2/11/2016 1:30 PM

I think you need to check when it quits and see if you have spark at the plug, if no spark disconnect the kill button. If you have spark check the fuel pump to see if your getting gas.